We have available NEW This Unit 1 power block is a coal-fired electric generating unit comprising a nominal 600 MW GE steam turbine, tandem-compound 4-flow single reheat unit with throttle conditions of 3500 psig, 1050°F/1100°F.  The Alstom steam generator is rated at approximately 4,650,000 lbs per hour capable of burning bituminous coal only or a combination of bituminous coal and petcoke (up to a 70%/30% blend). Coal pulverizers have significant design margin operating at ~70% for MCR firing.

 

The plant design heat rate with this power block is 8725 BTU/kw-hr with turbine control valves wide open (VWO) and average ambient conditions in southeastern U.S. with a circular mechanical forced draft cooling tower, an electrostatic precipitator, and a wet limestone flue gas desulphurization system. All cycle design has been incorporated into the equipment for sale and cycle information is available for all other normally desired conditions.

Included with the block procurement of the equipment listed for sale is the design documentation of the power block. This includes all drawings, specifications, calculations, 3D modeling etc. at the stage that currently exists. For sale separately are the continued services of the engineer of record for this design. As summary of the status of design is as follows.

 

The asking price for everything is $267,800,000.00 USD.  If you are interested please let us know so we can provide more details.  We  already have an NDA and Commission agreement in place with the owner.

 

600 MW SUPERCRITICAL GENERATING STATION POWER BLOCK  Equipment for Sale
DESCRIPTION	VENDOR NAME OR OTHER INFORMATION	SCOPE OF SUPPLY
TURBINE GENERATOR AND ACCESSORIES	GENERAL ELECTRIC
		Steam Turbine and Generator
		Two Boiler Feed Pump Turbines
		Turbine Lube and Hydraulic Oil System
		Steam Turbine and BFPT Mark VI control system
		Bently Nevada vibration monitoring system
		Generator Stator Cooling Water Skid
		Generator Protection Panel
		Generator Neutral Grounding Equipment
		Excitation Transformer and Equipment
		Steam Packing Exhauster
STEAM SURFACE CONDENSER	YUBA HEAT TRANSFER LLC
		3-Vacuum Pumps and Drives
		Condenser Neck Piping, Expansion Joints, Turbine Exhaust Expansion Joint, Neck Thermocouples, and Pipe Lagging
		2-Boiler Feed Pump Turbine Exhaust Duct Systems, including Butterfly Valves and Pressure-Balanced Expansion Joints
		Rupture Discs (BFPTD Exhaust Ducts)
		Condenser Tube Cleaning System
		Inlet and Outlet Circulating Water Expansion Joints
CONDENSATE PUMPS	RUHRPUMPEN
		3-Condensate Pumps with  accessories
		Electric Motor Drives
		Bently Nevada vibration monitoring system
FEEDWATER HEATERS	YUBA HEAT TRANSFER LLC
		LP Feedwater Heaters 1-1A & 1-1B
		LP Feedwater Heaters 1-2, 1-3, & 1-4
		HP Feedwater Heaters 1-6A/B, 1-7A/B, & 1-8A/B
		Drain Coolers 1A & 1B
BOILER FEED PUMPS, BOOSTER PUMPS & S/U PUMP	FLOWSERVE, INC.
		2-Boiler Feed Pumps with accessories
		2Boiler Feed Booster Pumps, Motors and lube oil systems
		110% Startup Boiler Feed Pump, motor and lube oil system
		Bently Nevada vibration monitoring system for booster pumps and Startup BFP.  Vibration sensors and proximitors only for main BFPs
		1Complete spare BFP inner assembly including rotor, inner casing, balancing device, seals, etc.
		1Complete spare  booster pump rotor
STEAM GENERATOR ENGINEER AND SUPPLY	ALSTOM POWER
		Air Heaters
		Air Heater leakage control system, hot spot detection system and associated PLC control system
		PA Fans, Motors, and Lubrication Systems
		Pulverizers, Motors, and Lubrication Systems
		Feeders
		Startup Boiler Circulating Water Pump
		Sootblowing System
		SCR with Sonic Air Horn Cleaning system
		SCR Catalyst
		Boiler Building structural steel, roof cap
		Boiler Building Platforms
		Instrumentation
		Heat tracing for His Work
		Safety Valves
		Vent Stacks
		Steam Coils
		Coal Piping
		Permanent Elevator (Boiler Building)
		1-Auxiliary Steam to Air Heater 3A Steam Coil Temperature Control Valve
		1-Auxiliary Steam to Air Heater 3B Steam Coil Temperature Control Valve
		Boiler Building Steel
		Ductwork & Expansion Joints
		2 - Separators
		Boiler Drain Flash Tank
		Low-Energy Piping and Hangers within Building
		Feedwater Piping within Building
		Feedwater Piping Hangers within Building
		Steam Coil Drain Tank
CRITICAL PIPING	B.F. SHAW
		Main Steam
		Hot Reheat
		Cold Reheat
		Boiler Feedwater Discharge
		Critical Piping Temperature Elements and Thermowells
		Temperature elements and thermowells requiring full penetration welds in piping runs in Critical Piping scope.
HIGH PRESSURE VALVES #1, High Pressure Gate, Globe, and Check Valves	FLOWSERVE, INC.
		2- Main Steam BFP Turbine Isolation Valves  (Y-Pattern Globe) (6"1-MS-BV-1005-1, 1-MW-BV-1006-1)
		2- Feedwater Feed Pump Discharge Valves (16"Y-Pattern Globe) (1-FW-MBV-1010-1, 1-FW-MBV-1011-1)
		2- Feedwater Feed Pump Discharge Valves (16"Tilting Disc Check) (1-FW-UV-1010-1, 1-FW-UV-1011-1)
		2- Feedwater HP Heater Bypass Valves (10"Gate, Globe) (1-FW-BV-1013-1, 1-FW-MBV-1013-1)
		4- Feedwater Recirculation Isolation Valves (10�? 12"Gate) (1-FW-BV-1021-1, 1-FW-BV-1022-1, 1-FW-BV-1023-1, 1-FW-BV-1024-1)
		2- Feedwater Feed Pump Prewarm Valves (3"Stop-Check) (1-FW-BV-1028-1, 1-FW-BV-1029-1)
		2- Feedwater Feed Pump Prewarm Valves (3"Tilting Disc Check) (1-FW-UV-1028-1, 1-FW-UV-1029-1)
		1- Feedwater Startup BFP Discharge Valve (8"Tilting Disc Check) (1-FW-UV-1041-1)
		1- Feedwater BFP Booster Pumps LCV Discharge Valve (12"Tilting Disc Check) (1-FW-UV-1009-1)
HIGH PRESSURE VALVES #2, High Pressure Gate, Globe, and Check Valves	WEIR PUMPS
		1- Feedwater Startup BFP Discharge Valve (8"Gate) (1-FW-MBV-1041-1)
		1- Feedwater BFP Booster Pumps LCV Discharge Valve (12"Gate) (1-FW-BV-1009-1)
		1- Feedwater Feed Pump LCV Discharge Valve (12"Gate) (1-FW-BV-1037-1)
		4- Feedwater HP Heater Isolation Valves (Gate Valve) (1-FW-MBV-1010-2, 1-FW-MBV-1018-1, 1-FW-MBV-1011-2, 1-FW-MBV-1019-1)
		2- Feedwater Feed Pump Discharge to LCV Valves (12"Y-Pattern Globe) (1-FW-BV-1035-1, 1-FW-BV-1036-1)
SEVERE SERVICE CONTROL VALVES	SPX PROCESS EQUIPMENT - COPES VULCAN
		1Condensate Pumps Min Flow Recirculation Control Valve (1-CD-FCV-1014-1)
		2Main BFP Recirculation Control Valves (1-FW-FCV-1021-1, 1-FW-FCV-1022-1)
		2BFP Booster Pump Recirculation Control Valves (1-FW-FCV-1054-1, 1-FW-FCV-1055-1)
		1Startup BFP Recirculation Control Valve (1-FW-FCV-1052-1)
		1Main BFP Feedwater Supply Control Valve (1-FW-LCV-1037-1)
		1Startup BFP Feedwater Supply Control Valve (1-FW-LCV-1040-1)
		1Deaerator Level Control Valve (1-CD-LCV-1027-1)
		1BFP Booster Pumps Feedwater Control Valve (1-FW-LCV-1008-1)